| Citation: |
SUN Yue, QIU Xincai, ZHANG Jinlei, et al. Experimental methods and reformation mechanism of grouting reinforcement in fractured coal and rock masses[J]. Journal of Mine Automation，2025，51（6）：150-156. DOI: 10.13272/j.issn.1671-251x.2025040092
|
Grouting reinforcement technology for fractured coal and rock masses is characterized by high concealment, complex procedures, and high construction costs. It is relatively difficult to design grouting schemes and study the grouting reinforcement mechanism through in-situ underground experiments. At present, there are few studies focusing on the design of grouting schemes, and the grouting reformation mechanism has not been fully revealed. To address these issues, a grouting reinforcement test system applicable in laboratory settings was developed for fractured coal and rock masses. Specimens of fractured gypsum-based rock masses with low dispersion characteristics were prepared, and the water–cement ratio of the cement slurry was used as the experimental variable. Grouting reinforcement tests under different water–cement ratios were carried out in the laboratory using the constructed system, and the grouting reformation mechanism was revealed. The results showed that: ① after grouting and reformation, the peak stress of the fractured gypsum-based specimens ranged from 3.64 to 5.21 MPa, indicating that their bearing capacity was effectively improved compared to the initial average residual stress of 3.11 MPa. ② With the increase in the water–cement ratio, the viscosity and flowability of the cement slurry continuously improved. Even fractures with a width of approximately 0.1 mm were effectively filled under high water–cement ratios. The structural framework effect of the reformed specimens continued to strengthen. When the water–cement ratio increased from 1.00 to 1.50, the average peak stress of the grouted and reformed specimens rose from 3.79 MPa to 5.09 MPa, representing an increase of 34.30%. ③ Within a certain range, slurry with a high water–cement ratio significantly enhanced the integrity and mechanical properties of the fractured rock mass. This clarified that the essence of grouting reinforcement lay in the filling of fractures by the slurry and the formation of the structural framework effect.
| [1] |
刘峰,曹文君,张建明,等. 我国煤炭工业科技创新进展及“十四五”发展方向[J]. 煤炭学报,2021,46(1):1-15.
LIU Feng,CAO Wenjun,ZHANG Jianming,et al. Current technological innovation and development direction of the 14th Five-Year Plan period in China coal industry[J]. Journal of China Coal Society,2021,46(1):1-15.
|
| [2] |
ZHANG Yandong,ZHANG Wei,WANG Kaizhang,et al. Hydromechanical properties and engineering applications of weakly cemented soft rock in Jurassic strata[J]. ACS Omega,2023,8(18):16373-16383.
|
| [3] |
何满潮,谢和平,彭苏萍,等. 深部开采岩体力学研究[J]. 岩石力学与工程学报,2005,24(16):2803-2813. DOI: 10.3321/j.issn:1000-6915.2005.16.001
HE Manchao,XIE Heping,PENG Suping,et al. Study on rock mechanics in deep mining engineering[J]. Chinese Journal of Rock Mechanics and Engineering,2005,24(16):2803-2813. DOI: 10.3321/j.issn:1000-6915.2005.16.001
|
| [4] |
任伟光,周宏伟,薛东杰,等. 上保护层开采下煤岩强扰动力学行为与渗透特性[J]. 煤炭学报,2019,44(5):1473-1481.
REN Weiguang,ZHOU Hongwei,XUE Dongjie,et al. Mechanical behavior and permeability of coal and rock under strong mining disturbance in protected coal seam mining[J]. Journal of China Coal Society,2019,44(5):1473-1481.
|
| [5] |
彭瑞东,薛东杰,孙华飞,等. 深部开采中的强扰动特性探讨[J]. 煤炭学报,2019,44(5):1359-1368.
PENG Ruidong,XUE Dongjie,SUN Huafei,et al. Characteristics of strong disturbance to rock mass in deep mining[J]. Journal of China Coal Society,2019,44(5):1359-1368.
|
| [6] |
许延春,苗葳,宛志红,等. 底板加固改造工作面“双关键层”控水模型[J]. 煤矿安全,2023,54(5):63-71.
XU Yanchun,MIAO Wei,WAN Zhihong,et al. Model of water control "two key layers" in floor reinforcement and reconstruction working face[J]. Safety in Coal Mines,2023,54(5):63-71.
|
| [7] |
孙茂如,程桦,潘锐,等. 深部巷道注浆锚索锚注分析及返修控制研究[J]. 采矿与安全工程学报,2024,41(5):982-989.
SUN Maoru,CHENG Hua,PAN Rui,et al. Analysis of anchor cable grouting and repair control in deep roadway[J]. Journal of Mining & Safety Engineering,2024,41(5):982-989.
|
| [8] |
席义苗,司建锋,常毛毛,等. 大采高工作面回撤通道破碎顶板注浆改性控制技术研究[J]. 中国矿业,2024,33(增刊1):284-289.
XI Yimiao,SI Jianfeng,CHANG Maomao,et al. Grouting modification control technology for broken roof in the retreat channel of the large mining height working face[J]. China Mining Magazine,2024,33(S1):284-289.
|
| [9] |
肖同强,余子豪,李怀珍,等. 深部巷道围岩裂隙注浆加固浆液扩散规律研究[J]. 河南理工大学学报(自然科学版),2024,43(1):16-24.
XIAO Tongqiang,YU Zihao,LI Huaizhen,et al. Study on slurry diffusion law of grouting reinforcement for fractured surrounding rock in deep roadway[J]. Journal of Henan Polytechnic University(Natural Science),2024,43(1):16-24.
|
| [10] |
翟晓荣,吴基文,胡儒,等. 分岔煤层下分层再生顶板地面预注浆加固区域研究[J]. 煤炭科学技术,2022,50(11):30-39.
ZHAI Xiaorong,WU Jiwen,HU Ru,et al. Study on surface pre-grouting reinforcement layer of stratified regenerated roof under bifurcated coal seam[J]. Coal Science and Technology,2022,50(11):30-39.
|
| [11] |
吴学明,雷照源,文杰. “三软”煤层工作面煤壁片帮防治试验研究[J]. 煤炭科学技术,2022,50(9):20-29.
WU Xueming,LEI Zhaoyuan,WEN Jie. Experiment on prevention and control of coal wall spalling in three soft coal seam working face[J]. Coal Science and Technology,2022,50(9):20-29.
|
| [12] |
彭英华,华攸金,李希建,等. 破碎煤岩巷道注浆加固材料试验与应用[J]. 煤炭科学技术,2022,50(4):85-90.
PENG Yinghua,HUA Youjin,LI Xijian,et al. Experiment and application of grouting reinforcement material for broken coal and rock in roadway[J]. Coal Science and Technology,2022,50(4):85-90.
|
| [13] |
黄耀光,张天军. 深部高地应力巷道塑性破坏特征及注浆支护[J]. 采矿与安全工程学报,2019,36(5):949-958.
HUANG Yaoguang,ZHANG Tianjun. Plastic failure characteristics and grouting support of deep roadway with high ground stress[J]. Journal of Mining & Safety Engineering,2019,36(5):949-958.
|
| [14] |
李万里. 基于注浆支护的巷道围岩浆液扩散规律研究[J]. 能源与环保,2019,41(9):162-165.
LI Wanli. Study on slurry diffusion law of roadway surrounding rock based on grouting supporting[J]. China Energy and Environmental Protection,2019,41(9):162-165.
|
| [15] |
王兵强. 深部条带采空区注浆效果综合评价技术与应用[J]. 煤炭工程,2021,53(8):98-104.
WANG Bingqiang. Comprehensive evaluation of grouting effect in goaf of deep strip mining[J]. Coal Engineering,2021,53(8):98-104.
|
| [16] |
张琰岽. 综采工作面注浆锚索超前支护技术研究[D]. 青岛:山东科技大学,2020.
ZHANG Yandong. Study on advanced support technology of grouting anchor cable in fully mechanized mining face[D]. Qingdao:Shandong University of Science and Technology,2020.
|
| [17] |
张琰岽,张炜,郭佳炜,等. 一种用于煤岩体注浆的试验装置及其试验方法:ZL202111261513.4 [P]. 2024-01-12.
ZHANG Yandong,ZHAGN Wei,GUO Jiawei,et al. A testing device and method for grouting in coal-rock mass:ZL202111261513.4 [P]. 2024-01-12.
|
| [18] |
隋肃,柳华实,张国辉,等. 普通硅酸盐水泥对石膏制品吸水性及力学性能的影响[J]. 济南大学学报(自然科学版),2005(3):275-277. DOI: 10.3969/j.issn.1671-3559.2005.03.025
SUI Su,LIU Huashi,ZHANG Guohui,et al. The influence of cement on gypsum' mechanics and absorb-water performance[J]. Journal of Jinan University (Science and Technology),2005(3):275-277. DOI: 10.3969/j.issn.1671-3559.2005.03.025
|
| [19] |
彭家惠. 建筑石膏减水剂与缓凝剂作用机理研究[D]. 重庆:重庆大学,2004.
PENG Jiahui. Study on the mechanism of water reducer and retarder for building gypsum[D]. Chongqing:Chongqing University,2004.
|
| [20] |
黄玉兵,江贝,姚良帝,等. 裂隙岩体预应力锚注协同控制机制试验研究[J]. 采矿与安全工程学报,2025,42(2):294-305.
HUANG Yubing,JIANG Bei,YAO Liangdi,et al. Experimental study on the collaborative control mechanism of prestressed anchor and grouting in fractured rock mass[J]. Journal of Mining & Safety Engineering,2025,42(2):294-305.
|
| [21] |
崔宏瑞,孟祥瑞,程详,等.水玻璃-膨胀剂-粉煤灰水泥基复合注浆材料研发与试验[J/OL].中国矿业:1-11[2025-03-04]. http://kns.cnki.net/kcms/detail/11.3033.TD.20250429.1549.006.html.
CUI Hongrui,MENG Xiangrui,CHENG Xiang,et al.Research and test of sodium silicate-expansion agent-fly ash cement-based composite grouting material[J/OL].China Mining Magazine:1-11[2025-03-04]. http://kns.cnki.net/kcms/detail/11.3033.TD.20250429.1549.006.html.
|
| [22] |
沈玉旭, 王成帅, 郭俊庆, 等. 基于正交试验的注浆材料力学性能及最优配比研究[J]. 矿业研究与开发,2025,45(5):63-71.
SHEN Yuxu, WANG Chengshuai, GUO Junqing, et al. Research on mechanical properties and optimal ratio of grouting materials based on orthogonal test[J]. Mining Research and Development,2025,45(5):63-71.
|
Supported by: Beijing Renhe Information Technology Co.,
Ltd. Visits：1484380
DownLoad: