基于容量增量法的防爆锂电池老化指标分析

陈继永, 吴兆宏, 李金喜

陈继永,吴兆宏,李金喜.基于容量增量法的防爆锂电池老化指标分析［J］.工矿自动化，2019,45（12）：29-34.. DOI: 10.13272/j.issn.1671-251x.2019080003
引用本文: 陈继永,吴兆宏,李金喜.基于容量增量法的防爆锂电池老化指标分析［J］.工矿自动化，2019,45（12）：29-34.. DOI: 10.13272/j.issn.1671-251x.2019080003
shu
CHEN Jiyong, WU Zhaohong, LI Jinxi. Aging indexes analysis of explosion-proof lithium battery based on incremental capacity method[J]. Journal of Mine Automation, 2019, 45(12): 29-34. DOI: 10.13272/j.issn.1671-251x.2019080003
Citation: CHEN Jiyong, WU Zhaohong, LI Jinxi. Aging indexes analysis of explosion-proof lithium battery based on incremental capacity method[J]. Journal of Mine Automation, 2019, 45(12): 29-34. DOI: 10.13272/j.issn.1671-251x.2019080003
shu

基于容量增量法的防爆锂电池老化指标分析

  • 1.

    江苏工程职业技术学院 航空与交通工程学院， 江苏 南通226007

  • 2.

    江苏省智能网联汽车工程技术研究开发中心， 江苏 南通226007

  • 3.

    安标国家矿用产品安全标志中心， 北京100013

  • 4.

    中国矿业大学 信息与控制工程学院， 江苏 徐州221116

基金项目: 

南通市科技计划项目（JCZ18065）

详细信息

  • 中图分类号: TD525

Aging indexes analysis of explosion-proof lithium battery based on incremental capacity method

  • 1.

    School of Aviation and Transportation, Jiangsu College of Engineering and Technology, Nantong 226007, China

  • 2.

    Jiangsu Province Intelligent Network United Automobile Engineering Technology R&D Center, Nantong 226007, China

  • 3.

    Mining Products Safety Approval and Certification Center Co., Ltd., Beijing 100013, China

  • 4.

    School of Information and Control Engineering, China University of Mining and Technology, Xuzhou 221116, China

HTML全文

    摘要
  • 摘要: 现有防爆锂电池矿用机车电池管理系统中电池健康状态仅用于预测电池剩余使用寿命，不对电池老化原因进行分析，对电池维护缺乏指导意义。针对该问题，首先分析了导致锂电池老化的内部因素，即锂离子损耗、活性物质溶解、内阻增加；然后基于容量增量法原理，提出了一种防爆锂电池老化指标分析方法，根据锂电池容量增量曲线高度和横向位置分别对锂离子损耗、活性物质溶解、内阻增加导致的锂电池老化进行量化分析，得出了相应的老化指标；最后介绍了电池管理系统中计算锂电池容量增量和确定容量增量曲线峰谷点的方法。采用电池充放电试验分析了充放电次数和充放电倍率对电池老化的影响：防爆锂电池以较小充放电倍率操作时，随着充放电次数增加，锂电池老化主要为锂离子损耗和活性物质溶解导致的老化；增大电池充放电倍率对内阻增加导致的电池老化影响最大。该方法有助于防爆锂电池管理系统更准确地估算电池健康状态，并为电池维护和电池管理系统的参数设定提供依据。
    Abstract: State of health(SOH) in existing battery management system(BMS) for mine-used locomotive powered by explosion-proof lithium battery is only used to predict remaining service life of the battery, but not for cause analysis of battery aging, which has no guiding significance for battery maintenance. In order to solve the problem, internal factors leading to lithium battery aging were analyzed firstly that were lithium ion loss, dissolution of active substances and increase of internal resistance. Then an aging indexes analysis method of explosion-proof lithium battery was proposed which was based on incremental capacity(IC) method. According to height and transverse position of IC curve of lithium battery, lithium battery aging caused by lithium ion loss, dissolution of active substances and increase of internal resistance were analyzed quantitatively to obtain corresponding aging indexes. Finally, methods of calculating lithium battery IC and determining peak and valley of IC curve in BMS were introduced. The influences of charge and discharge number and charge and discharge ratio on battery aging were analyzed by battery charge and discharge tests The test results show that with increase of charge and discharge number, explosion-proof lithium battery aging is mainly caused by loss of lithium ion and dissolution of active substances when it is operated with a small charge and discharge ratio. Increasing charge and discharge ratio of the battery has the greatest influence on battery aging caused by increase of internal resistance. The method is good for BMS of explosion-proof lithium battery to estimate SOH more correctly and can provide basis for battery maintenance and BMS parameters setting.
    • HTML全文
    • 参考文献(0)
    • 相关文章
    • 施引文献(13)

  • 期刊类型引用(10)

    1. 梁敬梅，李翠花. 基于神经网络逼近器的液压支架多缸协同控制. 煤炭技术. 2023(05): 223-225 . 百度学术
    2. 姚玉维. 基于工业以太网的液压支架试验装置集散控制系统研究. 建井技术. 2023(03): 90-94 . 百度学术
    3. 李留政，王正国，刘贺伟，李济顺，薛玉君. 多卷筒提升装备液压制动器同步性能仿真. 液压与气动. 2023(08): 124-132 . 百度学术
    4. 胥世琳，费叶琦，马竹樵，潘知瑶，刘雨浩，闫业斌. 升降舞台的研究现状及发展趋势. 科技创新与应用. 2022(28): 72-74+78 . 百度学术
    5. 王浩坤. 多缸液压伺服控制系统设计及实验研究. 微型电脑应用. 2021(06): 139-142 . 百度学术
    6. 刘芳华，张进金，李欣，项文彬. 吊舱推进器安装平台的液压同步控制策略. 船舶工程. 2021(05): 105-110 . 百度学术
    7. 樊凯，刘慧，刘杰. 改进的萤火虫算法在双缸同步控制系统中的应用. 内燃机与配件. 2021(22): 233-234 . 百度学术
    8. 曹艳，戴丽莉，邓睿，路和. 矿井提升机液压制动系统的建模与仿真. 液压与气动. 2019(06): 69-74 . 百度学术
    9. 夏雪，张明. 绝缘纸筒热压粘合机液压系统的应用及故障分析. 液压气动与密封. 2019(08): 77-79 . 百度学术
    10. 梁晓龙. 综采工作面液压支架电气自动化关键技术的研究. 机械管理开发. 2019(11): 233-235 . 百度学术

    其他类型引用(3)

    • 资源附件(0)
计量
  • 文章访问数:  91
  • HTML全文浏览量:  21
  • PDF下载量:  31
  • 被引次数: 13
出版历程
  • 刊出日期:  2019-12-19

目录

摘要
HTML全文
    参考文献(0)
    相关文章
    施引文献(13)
    资源附件(0)

    /

    返回文章
    返回

    苏ICP备 05016349号-2

    本系统由 北京仁和汇智信息技术有限公司 开发  访问量：1224446    百度统计